Fall Construction Starts Soar 21 Percent
26 Dec, 2018
New construction starts in October climbed 21% to a seasonally adjusted annual rate of $864.0 billion, according to Dodge Data & Analytics. The substantial increase followed three straight months of decline, during which the pace of total construction starts fell 22% from the exceptionally strong volume reported back in June. Nonresidential building in October surged 53%, as several very large projects lifted the manufacturing plant, office building, and transportation terminal categories. Nonbuilding construction in October advanced 14%, supported by growth for public works while the electric utility/gas plant category bounced back from depressed activity in September. Residential building in October edged up a slight 2%, helped by improvement for multifamily housing. During the first ten months of 2018, total construction starts on an unadjusted basis were $679.1 billion, up 1% from the same period a year ago. The year-to-date gain for total construction starts was restrained by a 45% slide for the electric utility/gas plant category. If the electric utility/gas plant category is excluded, total construction starts during the first ten months of 2018 would be up 3% relative to the same period a year ago.
October’s data raised the Dodge Index to 183 (2000=100), up from September’s 150, marking the second highest reading for the Dodge Index so far in 2018 after June’s 192. Through the first ten months of 2018, the Dodge Index averaged 169, up slightly from the full year 2017 average of 166.
“During 2018, the presence of very large projects in a given month has played a considerable role in shaping the monthly pattern of activity, and in October it was nonresidential building that especially benefitted from the start of very large projects,” stated Robert A. Murray, chief economist for Dodge Data & Analytics. “These included a $2.4 billion petrochemical plant in Texas, the $1.4 billion Terminal One building at Newark Liberty International Airport, the $860 million expansion to the Las Vegas Convention Center, a $750 million Facebook data center in Utah, and a $655 million concourse expansion at Denver International Airport that’s part of that facility’s extensive upgrade. Earlier, decreasing construction starts for nonresidential building during this year’s third quarter raised some concern, suggesting that this sector may have already peaked and is now in decline. The strong October performance indicates that nonresidential building construction starts continue to proceed at an elevated pace, at least for the present.”
Murray continued, “The current year has also witnessed moderate growth for public works construction, helped by the greater federal funding for fiscal 2018 passed by Congress back in March as part of the omnibus appropriations legislation. For fiscal 2019 which began on October 1, the federal-aid highway program and EPA construction-related programs are operating under a continuing resolution through December 7, waiting for Congress to finalize spending levels. As for residential building, multifamily housing has shown renewed expansion this year after settling back in 2017, yet a more cautious lending stance by banks towards multifamily development may dampen multifamily construction starts next year.”
Nonresidential building in October was $358.3 billion (annual rate), up 53% from September’s lackluster amount. After registering heightened activity in June, led by the start of a $6.5 billion uranium processing plant in Oak Ridge TN and the $1.8 billion Spiral office tower in New York NY, nonresidential building retreated for three consecutive months before October’s upturn. Manufacturing plant construction in October jumped 189%, boosted by the start of a $2.4 billion propylene oxide and tertiary butyl alcohol plant in Channelview TX and a $1.6 billion natural gas processing plant in Douglas WY. Additional manufacturing plant projects included as October starts were a $400 million wood products plant in Lexington NC, a $400 million natural gas processing plant in Watford City ND, and a $320 million biofuel refinery in Lakeview OR. The commercial building structure types as a group increased 48% in October, strengthening after declines during the previous three months. New office construction starts in October climbed 123%, led by a $750 million Facebook data center in Eagle Mountain UT. There were eight additional office projects valued at $100 million or more that reached groundbreaking in October, including the $644 million office portion of the $1.3 billion Winthrop Square Tower in Boston MA, the $475 million office portion of the $600 million Marriott headquarters and hotel in Bethesda MD, and the $267 million office portion of a $1.0 billion mixed-use development in Detroit MI at the site of the former Hudson’s department store. Hotel construction in October advanced 59%, boosted by the $301 million hotel portion of Detroit’s $1.0 billion mixed-use development and the $218 million hotel portion of the $400 million expansion of the Resorts World Hotel and Casino in South Ozone Park NY. Warehouse construction in October grew 17%, helped by groundbreaking for a $225 million fulfillment center in Rialto CA and a $125 million Dollar Tree distribution center in Marengo OH. There were two commercial structure types that registered declines in October – commercial garages, down 5%; and store construction, down 16%.
The institutional side of nonresidential building increased 28% in October. Transportation terminal construction starts jumped 92%, with the boost coming from the start of the $1.4 billion Terminal One building at Newark Liberty International Airport and the $655 million concourse expansion project at Denver International Airport. The October entry for the concourse expansion project follows another $700 million concourse expansion project at Denver International Airport entered as a September construction start, as well as that airport’s $650 million main terminal upgrade project that was entered as a July
construction start. The amusement and recreational category in October climbed 89%, reflecting groundbreaking for the $860 million expansion of the Las Vegas Convention Center in Las Vegas NV, the $182 million convention center and casino portion of the Resorts World Hotel and Casino expansion in South Ozone Park NY, and the $177 million convention center portion of Detroit’s $1.0 billion mixed-use development. The healthcare facilities category had a strong October, rising 60% with the support of six projects valued at $100 million or more, including a $282 million outpatient facility in Richmond VA and a $242 million hospital in Wexford PA. Also showing growth in October was the public buildings category, up 95% from a weak September, helped by the start of a $140 million courthouse addition in Charlotte NC. Educational facilities, the largest institutional category, ran counter to most of the other institutional structure types with an 18% decline in October. The largest educational facility projects entered as October construction starts were an $85 million renovation to a research laboratory in Boston MA, a $77 million high school in Cottonwood Heights UT, and a $71 million high school in Seaside OR. The religious building category also weakened in October, dropping 18%.
Nonbuilding construction in October was $184.0 billion (annual rate), up 14% following September’s 13% decline. The electric utility/gas plant category increased 187% relative to a very weak September, although October’s volume was still 32% less than the average monthly pace reported during 2017. Large electric utility projects that reached groundbreaking in October were a $334 million wind farm in Kansas and a $300 million wind farm in Minnesota. The public works categories as a group rose 6% in October, with a varied performance by individual category. Highway and bridge construction starts climbed 26%, with October coming in as the highest seasonally adjusted monthly amount so far in 2018. Large highway and bridge projects in October were led by the $1.3 billion U.S. portion of the Gordie Howe International Bridge (estimated at $2.6 billion in U.S. dollars for the entire bridge), connecting Detroit MI and Windsor Ontario. Other large highway and bridge projects in October were the $802 million I-395 project in Miami FL and the $673 million I-10 Corridor project in San Bernardino CA. The top five states ranked by the dollar amount of highway and bridge construction starts in October were – Texas, Michigan, Florida, California, and Pennsylvania. River/harbor development in October advanced 114%, reflecting a $210 million harbor dredging project in Jacksonville FL. Water supply construction grew 30% in October, boosted by a $121 million water supply conduit project in Burbank CA. The miscellaneous public works category pulled back 33% in October from its heightened September pace, which included the $1.4 billion Arbuckle II natural gas pipeline in Texas and Oklahoma, as well as the $1.1 billion Cactus II oil pipeline in Texas. The October data did include the start of one major pipeline project – the $2.0 billion Gray Oak oil pipeline that will transport crude oil from the Permian Basin to the Corpus Christi TX area. Through the first ten months of 2018, pipeline construction starts totaled $19.3 billion, down only 8% from the robust amount during the same period of 2017. Sewer construction also retreated in October, falling 40%.
Residential building in October was $321.7 billion (annual rate), rising 2%. The lift came from multifamily housing, which increased 15% in October. There were 13 multifamily projects valued at $100 million or more that were reported as October starts, compared to six such projects in September. The large multifamily projects in October included the $580 million multifamily portion of the Winthrop Square Tower in Boston MA, the $535 million Veyoel Moshe Gardens residential development in the Poughkeepsie NY area, the $300 million Laurel multifamily complex in Philadelphia PA, and the $184 million multifamily portion of Detroit’s $1.0 billion mixed-use development. Through the first ten months of 2018, the top five metropolitan areas ranked by the dollar amount of multifamily starts (with their percent change from a year ago) were – New York NY (up 3%), Boston MA (up 91%), Miami FL (up 44%), Washington DC (up 20%), and Seattle WA (up 25%). Metropolitan areas ranked 6 through 10 were – San Francisco CA (up 11%), Los Angeles CA (down 31%), Dallas-Ft. Worth TX (up 24%), Atlanta GA (down 15%), and Chicago IL (down 43%). Single family housing in October decreased 4%, as affordability constraints continue to make it difficult for this project type to register any sustained upward movement during 2018. By geography, October showed single family declines in four of the five major regions – the Northeast, down 10%; the South Central, down 8%; the West, down 6%; and the Midwest, down 5%. Only the South Atlantic, growing 4%, was able to post a single family gain in October.
The 1% increase for total construction starts on an unadjusted basis during the first ten months of 2018 was due to mixed behavior by the three major construction sectors. Residential building maintained its 6% lead over last year, with the dollar amount for both single family housing and multifamily housing up 6%. Nonresidential building year-to-date slipped 2%, with institutional building down 8%, commercial building down 3%, and manufacturing building up 32%. Nonbuilding construction year-to-date dropped 4%, as a 5% increase for public works was outweighed by the 45% plunge for electric utilities/gas plants. By major region, total construction starts during the January-October period of 2018 showed this pattern compared to a year ago – the South Central, up 11%; the Midwest and South Atlantic, each up 5%; the West, down 1%; and the Northeast, down 18%. The year-to-date decline in the Northeast was relative to the robust first ten months of 2017 that included such construction starts as the $7.6 billion LaGuardia Airport project in Queens NY, a $5.8 billion ethane cracker facility in Monaca PA, the $1.7 billion 50 Hudson Yards office tower in New York NY, the $1.6 billion Moynihan Station rail terminal project in New York NY, and the $1.4 billion Penn Medicine Patient Pavilion in Philadelphia PA.
About Dodge Data & Analytics: Dodge Data & Analytics is North America’s leading provider of analytics and software-based workflow integration solutions for the construction industry. Building product manufacturers, architects, engineers, contractors, and service providers leverage Dodge to identify and pursue unseen growth opportunities and execute on those opportunities for enhanced business performance. Whether it’s on a local, regional or national level, Dodge makes the hidden obvious, empowering its clients to better understand their markets, uncover key relationships, size growth opportunities, and pursue those opportunities with success. The company’s construction project information is the most comprehensive and verified in the industry. Dodge is leveraging its 100-year-old legacy of continuous innovation to help the industry meet the building challenges of the future. To learn more, visit www.construction.com.